Only quite recently, we have shown that yeast strains Clavispora lusitaniae 146 and Pichia fermentans 27 can act as efficient biocontrol agents for combating postharvest fungal diseases in lemons. During postharvest and storage conditions, microorganisms are subject to different stress factors that could affect both their survival and their protective capacity. Understanding the tolerance of yeasts to environmental stress factors could support the future development and commercial application of biological control formulations based on such organisms. Thus, the impact of different stressors on the viability and protection efficiency of C. lusitaniae strain 146 and P. fermentans strain 27 was evaluated, and the yeasts were subjected to oxidative stress, thermal treatments, exposure to NaOCl, osmotic stress, and ultraviolet irradiation. Candida oleophila strain O served as the reference control. C. lusitaniae 146 was more resistant to H2O2 in plate assays; however, in liquid media there was no significant difference to the other strains. Strain 146 was less affected by NaOCl, being able to survive with 300 ppm. P. fermentans 27 was the strain most heavily affected by osmotic pressure, while strains 146 and strain O showed a similar adaptation. UV-B irradiation severely affected C. oleophila and P. fermentans, while C. lusitaniae was the most resistant. Strains 146 and 27 were similarly tolerant to thermal shocks, compared to the reference strain, which was less viable. In in vivo tests, exposure to 10 mM H2O2, 45°C or 200 ppm NaOCl prior to fruit inoculation, reduced the antagonistic activity against the pathogen Penicillium digitatum. However, in no case was the biocontrol efficiency reduced to less than 50%. As C. lusitaniae 146 demonstrated a great potential to combat P. digitatum under a wide range of conditions, the organism is a promising candidate as an effective and valuable alternative to toxic fungicides.
Citation: Pereyra MM, Díaz MA, Meinhardt F, Dib JR (2020) Effect of stress factors associated with postharvest citrus conditions on the viability and biocontrol activity of Clavispora lusitaniae strain 146. PLoS ONE 15(9): e0239432. https://doi.org/10.1371/journal.pone.0239432
Editor: Sabrina Sarrocco, Universita degli Studi di Pisa, ITALY
Received: April 16, 2020; Accepted: September 6, 2020; Published: September 18, 2020
Copyright: © 2020 Pereyra et al. This is an open access article distributed under the terms of the Creative Commons Attribution License, which permits unrestricted use, distribution, and reproduction in any medium, provided the original author and source are credited.
Data Availability: All relevant data are within the manuscript.
Funding: This work was partially funded by “Proyecto PIUNT A618/2”. Martina María Pereyra and Mariana Andrea Diaz received a PhD fellowship from CONICET. The funders had no role in study design, data collection and analysis, decision to publish, or preparation of the manuscript.
Competing interests: The authors have declared that no competing interests exist.
Microbes displaying biocontrol activities against fungal pathogens have repeatedly been used for preventing postharvest diseases occurring during the storage and transport of fruits and vegetables [1–5]. Due to their proven safety they shaped up as a powerful alternative to chemical fungicides [6, 7], concomitantly offering the possibility of promoting sustainable agriculture based on organic fruit production . Among the different microbial biocontrol agents, antagonistic yeasts and research on them were prioritized  as they regularly devoid of mycotoxins or allergenic spores . The majority of such yeasts are not pathogenic for humans  and they can grow in environments with low water activity as well as limited nutrient availability and low oxygen levels . Candida oleophila is considered a biocontrol model for fighting postharvest fruit diseases and, consequently, commercial products have been released to the market and are still available [13–15]. Besides C. oleophila-containing products, which have proven to have certain efficiency in citrus protection, so-called killer yeasts, highly efficient in the specific protection of lemons against fungal postharvest infections, have been isolated only quite recently. Clavispora lusitaniae strain 146 [16, 17] and Pichia fermentans strain 27  isolated from lemon fruits arose as biocontrol agents for combating the green mold Penicillium digitatum, the most relevant fungus causing postharvest diseases in lemon.
Contrary to chemical agents, the action of yeasts as biocontrol agents largely depends on the prevailing environmental conditions and the organisms´ response to ecological parameters (temperature, salt stress, oxidative stress, UV-B irradiation) . Solar radiation, for instance, impacts the survival of the antagonist . The lemons industry routinely keeps postharvest and storage conditions as stable as possible ; however, inherent to the system, fruits are exposed to different factors that influence the performance of the biocontrol agent . During packaging, chemical disinfection  and drying processes  can significantly impact the yeast cells viability. Moreover, oxidative stress triggered by reactive oxygen species, such as hydrogen peroxide (H2O2) emerging in wounds of the fruit, can negatively affect the protective effects . Hence, knowledge of the conditions for the optimal growth and development is crucial to guarantee a level of protection that meets the requirements of the industry . Since the ability of the killer yeasts to resist conditions associated with packaging processes that affect their preventive capacity is unknown, the purpose of this work is to study the response of biological control strains C. lusitaniae 146 and P. fermentans 27 to stress conditions routinely associated with postharvest and packaging of the lemon fruits in comparison to the reference C. oleophila strain O.
Materials and methods
The organisms used in this study were Clavispora lusitaniae strain 146 (NCBI accession number KY442860) and Pichia fermentans strain 27 (KY442834), previously isolated from citrus fruits and selected due to their capability to function in biological control of the green mold disease of lemons . Candida oleophila strain O  was used as the reference control. The organisms were cultivated in liquid Yeast Extract Peptone Dextrose (YEPD) medium (pH 4.5) and stored on YEPD agar plates at 8°C.
As the biocontrol target organism Penicillium digitatum from the citrus fungi collection of the Phytopathology Laboratory of San Miguel S.A citrus company was selected due to its postharvest aggressiveness for lemon fruits. Spore suspensions were obtained after inoculation of lemon fruits with P. digitatum. When fruits were completely covered by the fungus (usually after 5 days at 25°C) spores were collected in standard saline solution containing 0.1% Tween 80.
Yeasts survival evaluation under stress conditions
Sensitivity of yeast cells to oxidative stress induced by hydrogen peroxide (H2O2).
The sensitivity assay of C. lusitaniae 146, P. fermentans 27 and C. oleophila strain O to oxidative stress followed the protocol established by Spencer et al. , with modifications. Cultures were grown in YEPD liquid medium at 25°C for 24 h and adjusted to a final concentration of 108 cells/mL using a Neubauer cell counting chamber. For evaluating resistance levels, 5 μL of ten-fold serial dilutions of each of the strains were spotted on YEPD agar containing 1 mM, 2.5 mM, 5 mM, 10 mM, 12.5 mM and 15 mM of H2O2. For control purposes, cells were spotted on YEPD agar without H2O2 and—as for the H2O2 containing samples—incubated for 48 h at 25°C prior to growth determination.
Monitoring viability: 20 mL suspensions (108 cells/mL) were exposed to different H2O2-concentrations (5 mM, 10 mM, 20 mM, 100 and 200 mM) and cultivated in an orbital flat shaker (Bioamerican Science, BS 875) for 15 min at 120 rpm. Cells were pelleted and washed twice with saline solution before being serially diluted. 100 μL of yeast suspensions (108 cells/mL) were plated on YEPD agar. Viability was monitored by counting colonies occurring after 48 h of incubation at 25°C. Both, the spot assays and the viability tests were done in triplicate.
Survival of yeast cells after sodium hypochlorite (NaOCl) treatment and exposure to sodium chloride (NaCl).
Yeasts sensitivity to sodium hypochlorite was assessed as described in Kwolek-Mirek et al. . As for the H2O2 assays cells were grown in YEPD medium for 24 h and adjusted to 108 cells/mL. Cultures were ten-fold serially diluted and 5 μL of each dilution were spotted on solid YEPD medium containing 0 ppm, 50 ppm, 100 ppm, 150 ppm, 200 ppm, 300 ppm and 400 ppm of NaOCl. Subsequently, plates were incubated at 25°C for 48 h and growth was monitored.
Monitoring viability: 20 mL of liquid cultures (108 cells/mL) containing 100 ppm, 200 ppm, 300 ppm and 400 ppm of NaOCl were shaken (Bioamerican Science, BS 875) at 120 rpm for 15 min. Subsequently, cultures were washed twice with saline solution, serially diluted and 100 μL of yeast suspensions were plated on YEPD agar. Petri dishes were incubated under the same conditions as described above. The number of CFUs per milliliter (CFU/mL) was determined after 48 h at 25°C.
Assessment of the influence of saline stress on the yeast strains: cells were exposed at increasing time-intervals to 6 M NaCl essentially as described in Wang et al. . 10 mL cell suspensions (108 cells/mL) were pipetted into a 50 mL centrifuge tube and exposed to 6 M NaCl for 30, 60, 120, 180 and 240 min at 25°C on a rotary shaker (Bioamerican Science, BS 875) at 120 rpm. At the above timely intervals, 100 μL of ten-fold serial dilutions were spread on solid YEPD and incubated for 48 h prior to determining the CFU/mL. All assays were carried out in triplicate.
Effect of UV-B irradiation on the viability of the biocontrol yeast strains.
For determining the effect of UV-B irradiation on the yeast strains used in this study, spot assays were performed. As for above assays ten-fold serial dilutions of each strain culture (108 cells/mL) were spotted on YEPD medium and after inoculation immediately exposed to UV-B irradiation (using a Vilbert Lourmat VL-4 lamp with maximum intensity at 312 nm) essentially as described in Portero et al. . Petri dishes were covered with cellulose acetate film to get rid of the UV-C part. Inoculated plates were exposed to UV-B irradiation at 2.98 W/m2 for 0 h, 0.5 h (5.36 Kj/m2), 1 h (10.73 Kj/m2), 1.5 h (16.09 Kj/m2), 2 h (21.46 Kj/m2), 2.5 h (26.82 Kj/m2) and 3 h (32.18 Kj/m2). Subsequently, strains were immediately kept in the dark for 48 h at 25°C to prevent photoreactivation.
The relative growth inhibition was estimated as follows: four plus signs (++++) when the yeasts´ growth was the same as the control, three plus signs (+++) when was slightly less than the control, two plus signs (++) when was partial inhibition, one plus sign (+) when a strong inhibition was; or with a negative sign (-) when no growth was observed.
Assaying thermotolerance after heat shock.
Thermal treatment was done according to Liu et al. , with some modifications: yeast cell suspensions (108 cells/mL) were subjected to 45°C and 50°C for 3 min, 5 min and 10 min. Immediately after heat treatment, cells were cooled on ice and serially diluted for proper determination of the CFU/mL on YEPD agar. The control consisted of yeast cell suspensions that were not exposed to any heat treatment (0 min). All plates were incubated at 25°C for 48 h followed by colony counting.
Capability test for biocontrol of stressed yeast strains with P. digitatum as the target
Biocontrol activities of C. lusitaniae 146, P. fermentans 27 and C. oleophila strain O was performed as described by Perez et al. . Lemon fruits were disinfected with 70% ethanol solution and were wounded in the equatorial zone by using an awl (one wound per lemon). 20 μL-suspensions (108 cells/mL) of non-treated or treated yeast cells (with 10 mM of H2O2 for 15 min, 200 ppm of NaOCl for 15 min or heated 5 min at 45°C) was applied to each wounded site. After 24 h of incubation at 25°C, each of the fruits was inoculated at the wounded site with 20 μL of a spore suspension of P. digitatum (1x106 spores/mL). The fruits were subsequently kept stored in closed plastics bags under high humidity (95%) at 25°C for 5 days. Three replicates with ten lemon fruit for each treatment were performed. Ten additional lemons were taken as the control; they were wounded and inoculated solely using the spore suspension of the phytopathogenic P. digitatum.
All experiments were repeated at least three times. The data were analyzed by ANOVA, and the mean values were compared with Tukey’s test at the 5% significance level. The InfoStat/L software  was used for the statistical analysis.
Sensitivity to hydrogen peroxide-induced oxidative stress
When the biocontrol strains were exposed to increasing H2O2 concentrations in solid medium it turned out that, in each case, viability was negatively affected by the oxidative agent (Fig 1A). While P. fermentans 27 was already completely inhibited by 5 mM H2O2, C. oleophila strain O survived up to 10 mM. C. lusitaniae 146 displayed the most prominent resistance to the hydrogen peroxide-induced oxidative stress as it survived the highest concentration tested (15 mM H2O2). All of the strains were able to survive 200 mM H2O2 when exposed for 15 min (Fig 1B). At 20 mM H2O2, the viability of C. oleophila strain O and P. fermentans 27 decreased compared to C. lusitaniae 146; a significant decrease occurred already in 100 mM H2O2. At 200 mM, viability of strain 146 (90.44%) and strain O (91.94%) was significantly greater than that of strain 27 (83.12%).
(A) Liquid YEPD-cultures of C. lusitaniae 146, P. fermentans 27 and C. oleophila strain O were ten-fold serially diluted and spotted onto YEPD agar containing the above specified H2O2 concentrations. Pictures were taken after 48 h at 25°C. (B) Viability of yeast cells referred in relation to the untreated control. Yeasts were exposed to the below specified H2O2 concentrations for 15 min. For details see Material and Methods 2.2.1. Mean values marked with identical letters are—according to the Tukey test (p <0.05)—not significantly different. Lowercase letters refer to the comparison between the maltreated strains and the respective control. Uppercase letters represent the comparison between yeasts at a certain condition.
Effect of sodium hypochlorite and 6 M sodium chloride on yeasts viability
When NaOCl was added to the solid medium, growth of C. lusitaniae 146 and P. fermentans 27 was seen up to 300 ppm (Fig 2A), both of the organisms turned out to be more tolerant to NaOCl than C. oleophila strain O, which survived only up to 200 ppm. Addition of NaOCl to liquid medium generated comparable results (Fig 2B). C. oleophila strain O tolerated up to 200 ppm of NaOCl with a viability of 84.96%, which is significantly lower than for C. lusitaniae 146 but greater than for P. fermentans 27 (96.19% and 70.49%, respectively); however, it failed to grow at higher concentrations. Resistance was observed for C. lusitaniae 146 even at 300 ppm, at least displaying a viability of 71.41%, unlike P. fermentans 27 that only reached 22.16% under the same conditions. 400 ppm NaOCl sufficed to inhibit growth at all.
(A) The organisms were grown on YEPD liquid medium, ten-fold serially diluted and spotted onto YEPD agar plates containing above specified concentrations of the disinfectant. Growth monitoring as in Fig 1. (B) For viability assays, strains were exposed for 15 min to 100 ppm, 200 ppm, 250 ppm, 300 ppm and 400 ppm NaOCl and survival was expressed in relation to the respective untreated control. Statistic evaluation as for Fig 1. Lowercase letters again correspond to the comparison between a strain and the respective control. Uppercase letters represent comparisons between yeasts at the specific conditions.
With respect to the survival after exposure to (lethal) 6 M NaCl, it turned out that—though the strains were able to tolerate the longest exposure time tested (240 min)—C. oleophila strain O and C. lusitaniae 146 performed significantly better than P. fermentans 27 (Fig 3). Viability of strain 146 decreased by 10.40%, similar to strain O (11.5%); strain 27 showed the lowest tolerance to NaCl as its viability decreased by 40% after 240 min in the concentrated saline solution.
Effect of UV-B irradiation on the in vitro viability of yeasts
For testing their tolerance to different intensities of UV-B irradiation the yeast strains were exposed to increasing energy doses. Results presented in Fig 4 and Table 1 show that—as expected—UV-B negatively influences survival in each case. Exposure to 10.73 Kj/m2 already severely hit C. oleophila strain O and P. fermentans 27 while C. lusitaniae 146 performed much better. Such effect is seen more pronounced at 32.18 Kj/m2 in Fig 4. Again C. lusitaniae 146 withstands the treatment much better than both of the other strains thereby confirming the results obtained at 10.73 Kj/m2. Fig 4 shows the outcome of assays in which 5 μL of ten-fold serial dilutions of cell suspensions containing 108 cells/mL were immediately irradiated after spotting. Table 1 summarizes results of more experiments performed with increasing UV-B doses. As can be seen from Fig 4 and Table 1, C. lusitaniae 146 scored best when exposed to UV-B.
Cells were ten-fold serially diluted, and 5 μL of each dilution was spotted onto YEPD agar. Subsequently, the plates were irradiated with UV-B at the indicated doses: 5.36 Kj/m2 (0.5 h), 10.73 Kj/m2 (1 h), 16.09 Kj/m2 (1.5 h), 21.46 Kj/m2 (2 h), 26.82 Kj/m2 (2.5 h) and 32.18 Kj/m2 (3 h). The figure exemplarily shows the control, without any exposure to UV-B, and those that been exposed for 1 h (10.73 Kj/m2) and 3 h (32.18 Kj/m2), respectively.
Thermotolerance of the yeast strains
For mimicking conditions during drying and waxing processes in lemon packinghouses, cells were exposed to thermal treatments for increasing periods of time. C. lusitaniae 146 and P. fermentans 27 withstood the 45 and 50°C treatments better than C. oleophila strain O (Fig 5A and 5B). As shown in Fig 5A, C. oleophila strain O and P. fermentans 27 resisted the heat up to 3 min without significant changes at 45°C, while C. lusitaniae 146 coped with such condition up to 5 min. After 10 min, strain 146 and strain 27 still displayed 97.11% and 98.12% viability, respectively, which is significantly higher than for strain O (70.67%). When the yeasts were subjected to 50°C (Fig 5B), the decrease of viability was more pronounced. After 5 min, a significant impact was seen for the strains 146 and O, whereas for P. fermentans 27 such decrease occurred only after 10 min. Thus, strain 27 most efficiently withstood the high temperatures, still displaying 98.12% and 86.54% survival rates at 45 and 50°C, respectively.
After exposure to 45°C (A) and 50°C (B) for 3, 5 and 10 min, cells were ten-fold serially diluted and plated on YEPD agar, followed by incubation at 25°C for 48 h. Mean values marked with identical letters are—according to the Tukey test (p <0.05)—not significantly different. Lowercase letters correspond to the comparison between each stressed yeast and its control. Uppercase letters represent the comparison between yeasts at a certain condition.
Biocontrol assay of stressed yeasts against P. digitatum
All the tested yeasts were exposed to selected stress conditions prior to evaluating in vivo their protecting capabilities against the phytopathogenic P. digitatum in lemons. The conditions applied were: exposure to 45°C for 5 min, exposure to 10 mM H2O2 for 15 min, and exposure to 200 ppm NaOCl for 15 min. All of the stressors affected the protecting efficiency. Regarding C. lusitaniae 146, exposure to NaOCl was the factor that most influenced the yeast biocontrol efficiency, since the obtained 59.26% was significantly lower than for cells without such treatment (Fig 6A). Both, thermal shock and H2O2 decreased the in vivo antagonistic activity of strain 146, but only the former significantly affected the viability with respect to the control. For P. fermentans 27 (efficiency in wound protection was 70% when not subjected to any stress) it turned out that—though the value is markedly lower than for the untreated strain 146 (96.67%) -neither the temperature, nor the oxidative stress induced by H2O2, nor exposure to NaOCl significantly affected the protection efficiency (Fig 6B). Finally, results presented in Fig 6C prove that the protection conferred by C. oleophila strain O was 66.67% and 59.26% when exposed to H2O2 and 200 ppm NaOCl, respectively, showing significant differences to the control. However, when the latter yeast was stressed by temperature, it still reached a protection efficiency of 76.67%, which does not differ significantly from that obtained in the control.
C. lusitaniae 146 (A), P. fermentans 27 (B) and C. oleophila strain O (C) were exposed to different stress factors (45°C for 5 min, 10 mM H2O2 for 15 min and 200 ppm NaOCl for 15 min) before evaluating its efficiency in controlling the pathogen. Mean values marked with identical letters are—according to the Tukey test (p <0.05)—not significantly different.
As we have previously shown, P. fermentans 27 and C. lusitaniae 146 can efficiently prevent postharvest fungal infections in lemons. Particularly the latter—due to its higher and consistent antagonistic activity—has been studied in some more detail. C. lusitaniae 146 colonizes wounded fruit, inhibits P. digitatum spore germination and it tolerates the waxes used in the citrus industry. Moreover, the strain depicts preventing efficacy even against a fungicide-resistant P. digitatum; even heat-inactivated cells of such yeast retain a certain level of control against fruit decays [16, 17].
Here—by comparing it with the reference C. oleophila strain O—we analyzed the response of such antagonistic yeasts (C. lusitaniae 146 and P. fermentans 27) to various modeled stress factors associated with pre- and postharvest conditions and packaging of lemon fruits. C. oleophila strain O, the reference, was originally isolated from apples and first studies demonstrated its biocontrol activity against Penicillium expansum and Botrytis cinerea in apples and pears . Its antagonistic capacity against citrus postharvest pathogens, such as P. digitatum and Penicillium italicum, was evaluated by Droby et al. . Two commercial C. oleophila-based products with an extended spectrum of action for protecting different fruits are currently available. The species is considered as the reference in biological control studies as its response to various stressors, such as water stress and low relative humidity has been studied ; more recently, Lahlali et al.  evaluated its response to UV-B irradiation.
Biological control agents can be significantly affected by several environmental factors ; oxidative stress being, undoubtedly, one of the most important factors as the fitness and the suitability of an organism for postharvest biocontrol depends on its capacity to resist oxidative stress . In the present report we show that effects of the oxidant on growth are more severe in solid than in liquid medium. Viability assays in liquid medium revealed that survival of C. lusitaniae 146, P. fermentans 27 and C. oleophila strain O treated with 200 mM H2O2 for 15 min were 90.44%, 83.12% and 91.94%, respectively. Findings reported by Liu et al. [28, 32, 33] strongly support our results; studying the tolerance of three antagonistic yeasts to oxidative stress they reported that the yeast Metschnikowia fructicola was most tolerant, displaying survival rates up to 88% after 20 min in 200 mM H2O2 ; the yeasts C. oleophila strain I-182  and Cystofilobasidium infirmominiatum  reached only 28% at 100 mM H2O2 and 23% in 20 mM H2O respectively, which are—despite of having used the same methodology in all cases—rather low values compared to those of the yeast strains studied here. Spencer et al.  examined the tolerance of yeasts to oxidative stress induced by H2O2 and showed that the yeasts Pichia guilliermondii, Candida shehatae, Candida succiphila and Scheffersomyces stipitis, when exposed to concentrations between 1 and 7.5 mM of H2O2 for 15 min, did not display a viability greater than 20% in any case, which is indicative of the high sensitivity of those yeasts to the oxidative stress, particularly when compared to the strains examined in this work.
For fighting bacteria and fungi, NaOCl at a concentration of 200 ppm is routinely added to the wash water in lemon packinghouses at the beginning of the packing process. Indeed, the compound is active against Staphylococcus aureus, Enterococcus faecalis, Pseudomonas aeruginosa, Bacillus subtilis, Listeria monocytogenes, Salmonella enteric , Candida albicans, Alternaria alternate [35–38] and Saccharomyces cerevisiae [39, 40]. The availability of biocontrol yeast strains able to tolerate such NaOCl concentrations is, thus, considered an important quality. As shown in this work, strains C. lusitaniae 146 and P. fermentans 27 survive 300 ppm NaOCl, the maximum concentrations tested. Strain 27 retained a viability of 22.16% while strain 146 lost only 30% of viability. For the reference strain C. oleophila, the NaOCl concentration used in packaging (200 ppm), resulted in a viability of 85%, but at higher concentrations, it hardly survived. Matching results were obtained in solid medium. Analogously, Kwolek-Mirek et al.  showed that NaOCl causes growth inhibition and loss of viability as well as metabolic activity in both wild-type yeast and antioxidant deficient mutants. However, unlike our findings, they reported the oxidant to be more effective at lower concentrations in liquid compared to solid medium, a finding that probably reflecting chemical reactions of the NaOCl with components of the solid medium.
When Wang et al.  performed a mild salt stress pretreatment of the strain C. oleophila I-182 to check whether such treatment increases the tolerance to the subsequent exposure to a lethal saline stress (6 M), they determined viability percentages for C. oleophila I-182 not adapted to stress reaching 52.2%, 41.2% and 34.6% for 30, 60 and 90 min, respectively, whereas cells with the saline pretreatment obtained values of 79.7%, 75.1% and 52.7%. In our study with C. oleophila strain O and for C. lusitaniae 146 after 240 min in 6 M NaCl, without a precedent saline adaptation treatment, we obtained viability values of 88.48% and 89.60%, respectively. Moreover, even for the maximum salt exposure time, the viability of P. fermentans 27 (59.91%) was greater than for C. oleophila I-182 not-stress-adapted at all, but less than that of the adapted cells after the first two exposure times. Thus, the killer yeasts investigated in this study are highly and more resistant to saline stress than the other known strains.
UV-B irradiation (280–320 nm), responsible for direct and indirect DNA damages, is among the most significant factors limiting survival of biocontrol agents under field conditions [2, 41, 42]. In the work carried out here, in vitro exposure to UV-B for 2 h or more (21.46 Kj/m2) resulted in the complete loss of viability of P. fermentans 27, while C. lusitaniae 146 after 3 h (32.18 Kj/m2) showed a greater tolerance to the irradiation than C. oleophila strain O. Results obtained for strain O are consistent with study reported by Lahlali et al. , which likewise mentions the total loss of viability after 3 h (2.79 Kj/m2) of UV-B irradiation despite the fact that the difference in the intensity of irradiation is significant, being notably greater in our study. The effect of UV-B irradiation on Pichia anomala strain K was evaluated in vitro by Lahlali et al. . Achieving a lethal dose of 90% needed an in vitro radiation at 1.6 Kj/m2, a finding that allows for strengthening the versatility of the yeasts studied here because for both, strain C. lusitaniae 146 and strain C. oleophila O, a markedly higher dose (32.18 Kj/m2) was required to obtain such low viability. Knowledge of the response of biocontrol agents to various environmental stresses is crucial for identifying antagonistic activity and the factors limiting survival of a biocontrol agent survival when applied as preharvest treatments .
As already mentioned, fruits are exposed to short-time thermal shocks in lemon packinghouses ranging from 45 to 50°C, primarily during drying and waxing. When our strains were thermally stressed, viability of all of the tested yeasts decreased as consequence to the rising temperatures. Nevertheless, they maintained high viability values even after 10 min at 50°C. Survival of C. lusitaniae 146, P. fermentans 27 and C. oleophila strain O were 82.18%, 86.54%, and 62.59%, respectively. Our findings are in line with reports on C. oleophila strain I-182 ; however, 30 min at 41°C depressed its survival to 22%. Viability of M. fructicola was 87% at 43°C  which clearly matches our results for C. lusitaniae 146 and P. fermentans 27. The temperature tolerance of two other biocontrol yeasts, Debaryomyces hansenii and Pichia membranaefaciens  was rather low as survival of D. hansenii dropped to less than 10% after 20 min at 40°C and viability of P. membranaefaciens reached only approximately 40% after 40 min at 50°C. An even more pronounced loss of viability was obtained for Pichia guilliermondii  as survival decreased to 4% when cells were heated for 15 min at 45°C. It is noteworthy that, as for the oxidative stress, yeasts differ considerably in their ability to withstand high temperatures, however, C. lusitaniae 146 and P. fermentans 27 perform rather robust.
In the biocontrol experiments using wounded lemon fruit, strain 146 and strain O provided higher levels of protection (96.67 and 93.33%, respectively) against P. digitatum than P. fermentans 27, the latter reached at least 70%. When yeasts were exposed to the different stressors, in some cases significant differences were observed compared to the respective control; in any case the efficiency in wound protection was less than 50%. More specifically, when cells were subjected to thermal stress (45°C, 5 min), the efficiency of C. lusitaniae 146, P. fermentans 27 and C. oleophila strain O reached 70%, 50%, and 76.67%, respectively. Under similar conditions (45°C, 20 min), Liu et al.  investigated the biocontrol activity of yeast M. fructicola against the phytopathogen P. expansum in apples determining a disease incidence of 43.3% (or a 56.7% protection efficiency). Such observation is consistent with the one for strain 27 and also reveals the higher temperature tolerance of strain 146 and strain O compared to M. fructicola. Moreover, we found that, unlike C. oleophila strain O, both C. lusitaniae 146 and P. fermentans 27 exposed to 10 mM H2O2 showed protection efficiency against P. digitatum without significant differences to the non-exposed yeasts. Thus, the two strains responded as was suggested by Castoria et al. , which stated that oxidative stress resistance is necessary for the yeast to remain viable and maintain biocontrol efficacy in the wounded fruit. Liu et al.  studied the effect of a pretreatment with 5 mM H2O2 for 30 min on the biocontrol activity of the yeast C. oleophila I-182 and found that the stress-adapted yeast displayed a greater level of efficacy than non-stress-adapted cells in controlling P. expansum and B. cinerea. Hypochlorite is an oxychlor compound attacking by oxidation many biological molecules, including proteins, fatty acyl chains, carbohydrates and nucleic acids [26, 37, 45]. The chlorine compound is often used as a disinfectant during the first steps in the citrus packing process and, consequently, it is important to investigate the response of potential biocontrol yeasts to such agent. The three strains exposed to NaOCl exhibited a decrease in the biocontrol of P. digitatum but, in the case of P. fermentans 27, there were no significant differences whereas their protection capabilities of C. lusitaniae 146 and C. oleophila strain O were notably lowered, reaching both 59.26%.
In this work, the resistance to stress conditions of the killer yeasts C. lusitaniae 146 and P. fermentans 27, previously known for their efficiency to prevent postharvest fungal diseases in lemons, was determined and compared to the C. oleophila strain O. The latter is considered as a reference strain in biocontrol assays and is the main component of well-known commercial formulations used for the biological control of postharvest fungal diseases.
C. lusitaniae 146 showed an outstanding behavior over the others strains, and by displaying an excellent ability to survive saline or oxidative stress, to resist disinfectants and to maintain viability when exposed to high levels of UV-B irradiation or against thermal shocks, it became a promising candidate for use as a biocontrol agent. Furthermore, it also maintained its capacity to control green mold in lemons even after the previous exposure to diverse stressors.
The capacity of C. lusitaniae 146 to withstand stress factors associated with preharvest or postharvest conditions, including packing processes, storage, transit or export, makes it a suitable candidate for generating a commercial formulation to combat postharvest fungal infections in lemons or possibly in other citrus fruits as well.
- 1. Droby S, Wisniewski M, Macarisin D, Wilson C. Twenty years of postharvest biocontrol research: is it time for a new paradigm?. Postharvest Biol Technol. 2009; 52(2): 137–145.
- 2. Ippolito A, Nigro F. Impact of preharvest application of biological control agents on postharvest diseases of fresh fruits and vegetables. Crop Prot. 2010; 19(8–10): 715–723.
- 3. Janisiewicz WJ, Korsten L. Biological control of postharvest diseases of fruits. Annu Rev Phytopathol. 2002; 40(1): 411–441. pmid:12147766
- 4. Liu J, Sui Y, Wisniewski M, Droby S, Liu Y. Utilization of antagonistic yeasts to manage postharvest fungal diseases of fruit. Int J Food Microbiol. 2013; 167(2): 153–160. pmid:24135671
- 5. Wilson CL, Wisniewski ME. Biological control of postharvest diseases of fruits and vegetables: an emerging technology. Annu Rev Phytopathol. 1989; 27(1): 425–441.
- 6. Morales H, Marín S, Ramos AJ, Sanchis V. Influence of post-harvest technologies applied during cold storage of apples in Penicillium expansum growth and patulin accumulation: A review. Food Control. 2010; 21(7): 953–962.
- 7. Viñas I, Vallverdú N, Monllao S, Usall J, Sanchis V. Imazalil resistant Penicillium isolates from Spanish apple packinghouses. Mycopathologia. 1993; 123(1): 27–33.
- 8. Teixidó N, Vinas I, Usall J, Sanchis V, Magan N. Ecophysiological responses of the biocontrol yeast Candida sake to water, temperature and pH stress. J Appl Microbiol. 1998; 84(2): 192–200.
- 9. Wisniewski M, Wilson C, Droby S, Chalutz E, El Ghaouth A, Stevens C. In: Vincent C, Goettel MS, Lazarovits G, editors. Biological control: A Global Perspective. Wallingford: CAB International; 2007. pp. 262–273.
- 10. Petersson S, Jonsson N, Schnürer J. Pichia anomala as a biocontrol agent during storage of high-moisture feed grain under airtight conditions. Postharvest Biol Technol. 1999; 15(2): 175–184.
- 11. Nally MC, Pesce VM, Maturano YP, Toro ME, Combina M, de Figueroa LC, et al. Biocontrol of fungi isolated from sour rot infected table grapes by Saccharomyces and other yeast species. Postharvest Biol Technol. 2013; 86: 456–462.
- 12. Fredlund E, Druvefors U, Boysen ME, Lingsten KJ, Schnürer J. Physiological characteristics of the biocontrol yeast Pichia anomala J121. FEMS Yeast Res. 2002; 2(3): 395–402. pmid:12702290
- 13. Droby S, Cohen L, Daus A, Weiss B, Horev B, Chalutz E, et al. Commercial testing of Aspire: a yeast preparation for the biological control of postharvest decay of citrus. Biol Control. 1998; 12(2): 97–101.
- 14. Jijakli M, Lepoivre P, Tossut P, Thonard P. Biological control of Botrytis cinerea and Penicillium sp. on post-harvest apples by two antagonistic yeasts. Mededelingen van de Faculteit Landbouwkundige en Toegepaste Biologische Wetenschappen. 1993; 58(3b).
- 15. Lahlali R, Serrhini MN, Jijakli H. Efficacy assessment of Candida oleophila (strain O) and Pichia anomala (strain K) against major postharvest diseases of citrus fruits in Morocco. Comm. Appl. Biol. Sci. Ghent University. 2004; 69(4): 601–609.
- 16. Pérez MF, Ibarreche JP, Isas AS, Sepúlveda M, Ramallo J, Dib JR. Antagonistic yeasts for the biological control of Penicillium digitatum on lemons stored under export conditions. Biol Control. 2017; 115: 135–140.
- 17. Pérez MF, Díaz MA, Pereyra MM, Córdoba JM, Isas AS, Sepúlveda M, et al. Biocontrol features of Clavispora lusitaniae against Penicillium digitatum on lemons. Postharvest Biol Technol. 2019; 155: 57–64.
- 18. Pérez MF, Contreras L, Garnica NM, Fernández-Zenoff MV, Farías ME, Sepúlveda M, et al. Native Killer Yeasts as Biocontrol Agents of Postharvest Fungal Diseases in Lemons. PloS one. 2016; 11(10): e0165590. pmid:27792761
- 19. Sui Y, Wisniewski M, Droby S, Liu J. Responses of yeast biocontrol agents to environmental stress. Appl Environ Microbiol. 2015; 81(9): 2968–2975. pmid:25710368
- 20. Lahlali R, Brostaux Y, Jijakli MH. Control of apple blue mold by the antagonistic yeast Pichia anomala strain K: screening of UV protectants for preharvest application. Plant Dis. 2011b; 95(3): 311–316. pmid:30743501
- 21. Lahlali R, Raffaele B, Jijakli MH. UV protectants for Candida oleophila (strain O), a biocontrol agent of postharvest fruit diseases. Plant Pathol. 2011a; 60(2): 288–295.
- 22. Macarisin D, Droby S, Bauchan G, Wisniewski M. Superoxide anion and hydrogen peroxide in the yeast antagonist–fruit interaction: a new role for reactive oxygen species in postharvest biocontrol? Postharvest Biol Technol. 2010; 58(3): 194–202.
- 23. Wang Y, Luo Y, Sui Y, Xie Z, Liu Y, Jiang M, et al. Exposure of Candida oleophila to sublethal salt stress induces an antioxidant response and improves biocontrol efficacy. Biol Control. 2018; 127: 109–115.
- 24. Castoria R, Caputo L, De Curtis F, De Cicco V. Resistance of postharvest biocontrol yeasts to oxidative stress: a possible new mechanism of action. Phytopathology. 2003; 93(5): 564–572. pmid:18942978
- 25. Spencer J, Phister TG, Smart KA, Greetham D. Tolerance of pentose utilising yeast to hydrogen peroxide-induced oxidative stress. BMC Res Notes. 2014; 7(1): 151. pmid:24636079
- 26. Kwolek-Mirek M, Bartosz G, Spickett CM. Sensitivity of antioxidant deficient yeast to hypochlorite and chlorite. Yeast. 2011; 28 (8): 595–609. pmid:21761455
- 27. Portero LR, Alonso‐Reyes DG, Zannier F, Vázquez MP, Farías ME, Gärtner W, et al. Photolyases and Cryptochromes in UV‐resistant Bacteria from High‐altitude Andean Lakes. Photochem and Photobiol. 2019; 95(1): 315–330. pmid:30485446
- 28. Liu J, Wisniewski M, Droby S, Tian S, Hershkovitz V, Tworkoski T. Effect of heat shock treatment on stress tolerance and biocontrol efficacy of Metschnikowia fructicola. FEMS Microbiol Ecol. 2011a; 76(1): 145–155. pmid:21223330
- 29. Di Rienzo JA, Casanoves F, Balzarini MG, Gonzalez L, Tablada M, Robledo CW. InfoStat versión, 2016. Grupo InfoStat, FCA. Universidad Nacional de Córdoba, Argentina. Available: http://www.infostat.com.ar
- 30. Lahlali R, Jijakli MH. Enhancement of the biocontrol agent Candida oleophila (strain O) survival and control efficiency under extreme conditions of water activity and relative humidity. Biol Control. 2009; 51(3): 403–408.
- 31. Wang Y, Wang P, Xia J, Yu T, Lou B, Wang J, et al. Effect of water activity on stress tolerance and biocontrol activity in antagonistic yeast Rhodosporidium paludigenum. Int J Food Microbiol. 2010; 143(3): 103–108. pmid:20805007
- 32. Liu J, Wisniewski M, Droby S, Vero S, Tian S, Hershkovitz V (2011b). Glycine betaine improves oxidative stress tolerance and biocontrol efficacy of the antagonistic yeast Cystofilobasidium infirmominiatum. Int J Food Microbiol. 2011b; 146(1): 76–83. pmid:21353322
- 33. Liu J, Wisniewski M, Droby S, Norelli J, Hershkovitz V, Tian S, et al. Increase in antioxidant gene transcripts, stress tolerance and biocontrol efficacy of Candida oleophila following sublethal oxidative stress exposure. FEMS Microbiol Ecol. 2012; 80(3): 578–590. pmid:22313238
- 34. Alonso-Hernando A, Alonso-Calleja C, Capita R. Effects of exposure to poultry chemical decontaminants on the membrane fluidity of Listeria monocytogenes and Salmonella enteric strains. Int J Food Microbiol. 2010; 137(2–3): 130–136. pmid:20056288
- 35. Cotter JL, Fader RC, Lilley C, Herndon DN. Chemical parameters, antimicrobial activities, and tissue toxicity of 0.1 and 0.5% sodium hypochlorite solutions. Antimicrobial Agents and Chemotherapy. 1985; 28(1): 118–122. pmid:3929674
- 36. Estrela C, Ribeiro RG, Estrela CR, Pécora JD, Sousa-Neto MD. Antimicrobial effect of 2% sodium hypochlorite and 2% chlorhexidine tested by different methods. Brazilian Dental Journal. 2003; 14(1): 58–62. pmid:12656467
- 37. Ingram PR, Homer NZ, Smith RA, Pitt AR, Wilson CG, Olejnik O, et al. The interaction of sodium chlorite with phospholipids and glutathione: a comparison of effects in vitro, in mammalian and in microbial cells. Arch Biochem Biophys. 2003; 410(1): 121–133. pmid:12559984
- 38. Ingram PR, Pitt AR, Wilson CG, Olejnik O, Spickett CM. A comparison of the effects of ocular preservatives on mammalian and microbial ATP and glutathione levels. Free Radic Res. 2004; 38(7): 739–750. pmid:15453639
- 39. Buschini A, Carboni P, Furlini M, Poli P, Rossi C. Sodium hypochlorite, chlorine dioxide and peracetic acid induced genotoxicity detected by the Comet assay and Saccharomyces cerevisiae D7 tests. Mutagenesis. 2004: 19(2): 157–162. pmid:14981163
- 40. Lewinska A, Bilinski T, Bartosz G. Limited effectiveness of antioxidants in the protection of yeast defective in antioxidant proteins. Free Radic Res. 2004; 38(11): 1159–1165. pmid:15621692
- 41. Teixidó N, Usall J, Vinas I. Efficacy of preharvest and postharvest Candida sake biocontrol treatments to prevent blue mould on apples during cold storage. Int J Food Microbiol. 1999; 50(3): 203–210.
- 42. Magan N. Physiological approaches to improving the ecological fitness of fungal biocontrol agents. In: Butt TM, Jackson C, Magan N, editors. Fungi as biocontrol agents: progress, problems and potential. CAB International Publishing, Wallingford; 2001. pp. 239–252.
- 43. An B, Li B, Qin G, Tian S. Exogenous calcium improves viability of biocontrol yeasts under heat stress by reducing ROS accumulation and oxidative damage of cellular protein. Current Microbiol. 2012; 65(2): 122–127. pmid:22562600
- 44. Sui Y, Liu J. Effect of glucose on thermotolerance and biocontrol efficacy of the antagonistic yeast Pichia guilliermondii. Biol Control. 2014; 74: 59–64.
- 45. Rees MD, Pattison DI, Davies MJ. Oxidation of heparan sulphate by hypochlorite: role of N-chloro derivatives and dichloramine-dependent fragmentation. Biochem J. 2005; 391(1): 125–134. pmid:15932347