Expression of Lactate Dehydrogenase in Aspergillus niger for L-Lactic Acid Production

Different engineered organisms have been used to produce L-lactate. Poor yields of lactate at low pH and expensive downstream processing remain as bottlenecks. Aspergillus niger is a prolific citrate producer and a remarkably acid tolerant fungus. Neither a functional lactate dehydrogenase (LDH) from nor lactate production by A. niger is reported. Its genome was also investigated for the presence of a functional ldh. The endogenous A. niger citrate synthase promoter relevant to A. niger acidogenic metabolism was employed to drive constitutive expression of mouse lactate dehydrogenase (mldhA). An appraisal of different branches of the A. niger pyruvate node guided the choice of mldhA for heterologous expression. A high copy number transformant C12 strain, displaying highest LDH specific activity, was analyzed under different growth conditions. The C12 strain produced 7.7 g/l of extracellular L-lactate from 60 g/l of glucose, in non-neutralizing minimal media. Significantly, lactate and citrate accumulated under two different growth conditions. Already an established acidogenic platform, A. niger now promises to be a valuable host for lactate production.


Introduction
Lactic acid is a versatile organic acid used in various industrial applications. It is a commonly used acidulant and preservative in food, leather, textile industries and helps in controlled drug delivery. Demand for lactic acid has increased in recent years due to two emerging productspolylactide (a biodegradable plastic) and ethyl lactate (an environment friendly solvent). The L (+) form of lactate is used in food and pharma industries as humans can assimilate this isomer [1]. Industrial scale biosynthesis of L-lactic acid is achieved through fermentation of microorganisms belonging to Lactobacillus, Bacillus and Rhizopus genera. Lactobacillus species were the first promising candidate for lactic acid production. They are fastidious with respect to growth requirements and cannot utilize starchy raw materials. Hence the pretreatment of raw materials raises the cost of production. Their growth is inhibited at low pH during lactate fermentation and the addition of neutralizing agents makes downstream processing difficult [1]. Amongst filamentous fungi Rhizopus oryzae is known to naturally produce lactate. But lactate production using this fungus requires near neutral pH conditions and yields are compromised due to formation of ethanol and fumarate as by-products [2,3]. Different organisms have been engineered to improve process parameters and increase lactate yields. Among fungi,

Material and Methods Strains and media
A. niger NCIM 565 (National collection of Industrial Microorganisms, National Chemical Laboratory-Pune, India) was the parent strain for this study. Different A. niger strains were maintained on potato dextrose (PDA) agar or yeast nitrogen base (without amino acids and ammonium sulfate), dextrose and ammonium nitrate (YDA) agar supplemented with DLphosphinothricin (PPT) (YDA+PPT agar for bar transformants). The PPT (technical grade sample from Bayer Crop-Science; supplied as 45-50% aqueous solution, w/v) at 1.0 mg/ml of final concentration was used for selection of transformants. The bar marker from plasmid pCB1265 was employed to select A. niger transformants. A. niger mycelia were harvested from shake flask cultures grown in minimal medium (MM) [25] for protein extraction and lactate fermentation. The MM contained 20.0 g/l glucose, 3.0 g/l KH 2 PO 4 , 6.0 g/l Na 2 HPO 4 , 0.5 g/l MgSO 4 .7H 2 O, 2.25 g/l NH 4 4 .H 2 O. The medium pH was adjusted with 0.1 N HCl to 5.5-6.0. For citrate production, A. niger growth was carried out in acidogenic medium (AM) containing 140.0 g/l sucrose, 1.0 g/l KH 2 PO 4 , 0.1 g/l Fe(NH 4 ) 2 (SO 4 ) 2 , 2.25 g/l NH 4 NO 3 and 0.25 g/l MgSO 4 .7H 2 O for eight days. A. niger strains were also grown in MM under conditions of hypoxia according to Terabayashi et al. [26].

Construction of heterologous and homologous ldh expression vectors
Mouse ldhA cDNA (NCBI accession number BC094019) was PCR amplified from a cDNA clone (pCMV from OriGene, USA), using the primers ldhNcF1 and ldhXbR1 ( Table 1). The amplicon (999 bp DNA encoding a 332 residue protein) was cloned between NcoI and XbaI sites in pCBΔXCE [24] by replacing the EGFP CDS. The resultant plasmid pCBΔXCmldh consisted of PcitA-mldhA expression cassette along with the bar selection marker. The putative A. niger ldh sequence (corresponding to An04g08220 of A. niger CBS strain) was PCR amplified (primers AnldhNcF1 and AnldhXR1; Table 1) from A. niger NCIM 565 genomic DNA. This amplicon was cloned between NcoI and XbaI sites of pCBΔXCmldh thereby replacing the mouse ldhA cDNA to obtain pCBΔXCAnldh.

A. niger transformation and characterization of transformants
A. niger was transformed and the A. niger transformants were selected on YDA+PPT agar [24]. Genomic DNA was isolated from mycelia using QIAGEN DNeasy Plant Mini kit. PcitA-mldhA copy number in the genome of A. niger mldh transformants was determined by qPCR (Stratagene Mx3000P; Agilent Technologies). The PcitA-mldhA fragment was amplified with CitF4 and mldhR4 primer pair ( Table 1). The single copy A. niger actin gene served as a reference and was amplified with actAF and actAR primers (Table 1). Amplification efficiencies were determined using serial dilutions (0.1-10 ng/μl) of genomic DNA. The qPCR reactions (in 20 μl) were performed in triplicates and each reaction mixture contained 10 μl 2× Brilliant III Ultra fastSYBR Green master mix (Agilent Technologies), 3 μl suitably diluted genomic DNA and 50 nM each of forward and reverse primers. The qPCR conditions were as follows: initial denaturation at 95°C for 3 min followed by 40 cycles of 95°C for 20 s, 61°C for 30 s. Melt curve analysis was performed to check for the presence of primer dimers and/or nonspecific products. The copy number was calculated according to Skulj et al. [28].

cDNA preparation
Total RNA from A. niger was prepared using QIAGEN RNeasy Plant Mini kit. A. niger ldhA cDNA was prepared from total RNA using Transcription first strand cDNA synthesis kit (Roche Diagnostics India Pvt. Ltd.). Oligo(dT) primers were used to generate cDNA which was subsequently purified using cDNA purification column (Invitrogen). The amplification of A. niger ldhA cDNA was done with gene specific primers AnldhNcF1 and AnldhXR1.
Preparation of cell-free extract and lactate dehydrogenase assay A. niger mycelial proteins were extracted with 2 volumes (cell wet weight:volume) of ice-cold extraction buffer (200 mM Tris-HCl pH 8.0, 1 mM 2-mercaptoethanol and 1 mM phenylmethanesulfonylfluoride). The cell-free extract was clarified at 12400×g for 20 min in a refrigerated centrifuge. For LDH assays, the final supernatant was desalted (on Sephadex G-25 column) before use. The LDH activity was determined in the direction of lactate oxidation, by measuring the NADH formed at 340 nm. The assay mixture composed of 100 mM Tris-HCl buffer (pH 8.0), 200 mM sodium L-lactate, 2.5 mM NAD + and suitably diluted A. niger cell-free extract. One unit of enzyme activity corresponds to the amount of enzyme that generates 1.0 nmole of NADH per min. The LDH activity was also monitored in the direction of pyruvate reduction (1.0 mM sodium pyruvate, 0.1 mM NADH in the same buffer as mentioned above, but at pH 7.4), when required. The LDH activity staining protocol was essentially as that for glutamate dehydrogenase [25], but using lactate and NAD + as substrates.
Analytical methods L-Lactate, citrate and glucose were estimated enzymatically. The assay mixture for lactate estimation consisted of 1.0 M glycine buffer (pH 9.5), 0.4 M hydrazine, 2.5 mM NAD + , 10 units of rabbit muscle L-LDH (Sigma Aldrich) and a suitable aliquot of the lactate sample. The mixture was incubated at 37°C for 60 min and absorbance at 340 nm was recorded. Appropriate enzyme blanks were included and L-lactate concentration was calculated using a standard curve. The lactate concentration was determined in millimolar (mM) units and 1 mM corresponds to 0.09 g/l. Citrate was estimated using citrate lyase (from Aerobacter aerogenes; Roche Diagnostics India Pvt. Ltd.) based on established procedure [29]. After an initial 15 min incubation with phenylhydrazine, the citrate sample was incubated for further 15 min with citrate lyase assay buffer. The absorbance of oxaloacetate phenylhydrazone was measured at 330 nm. Appropriate enzyme blanks were used to account for endogenous oxaloacetate contribution. Glucose was estimated using glucose oxidase-peroxidase reagent (Biolab Diagnostics Pvt. Ltd., India).
For intracellular lactate and citrate estimations, the A. niger mycelia were harvested by filtering through muslin cloth, washed with 3-5 volumes of distilled water, blotted dry and frozen immediately in liquid nitrogen. The whole operation was concluded within couple of minutes after harvest. The mycelia were crushed in liquid nitrogen and suitable buffer to obtain cellfree extracts. The cell-free extracts were treated with perchloric acid: methanol: water (8:40:52) mixture (10% of sample volume) to precipitate proteins and the precipitate cleared by centrifugation (10000×g for 5 min). Clear supernatants were neutralized with 1.0 M KOH before estimating the lactate/citrate present. The protocol employed here takes a few minutes and may not rapidly quench the mycelial metabolism [30]; to this extent, intracellular lactate and citrate measurements may be biased. However, their extracellular levels were better assessed as the samples were quickly filtered to remove mycelia and frozen. Intracellular concentration of lactate/citrate was calculated assuming an intracellular volume of 0.233 ml/g wet weight of A. niger mycelia [31].
Unless otherwise mentioned, all enzyme activity data and the metabolite measurements are representative of at least three separate experiments (performed in duplicates). Error bars represent the standard deviation.

Shake flask culture for lactate fermentation
The A. niger NCIM 565 and ldhA transformants were grown in MM supplemented with different glucose concentrations (1-10 percent). CaCO 3 (30 g/l) was added to MM for growth under neutralizing conditions. Different A. niger strains were inoculated (10 8 spores/100 ml) in 200 ml medium (in 1000 ml Erlenmeyer flasks) and the lactate levels were monitored for 7 days.

Results and Discussion
Search for a functional ldh locus in A. niger Use of A. niger as a host to produce lactate requires that an endogenous or heterologous ldh gene be expressed. Presence of a functional LDH is not reported in A. niger. Marginal but reproducible lactate oxidation activity was observed in the parent strain suggesting that an endogenous LDH-like enzyme may be present in A. niger. Lactate (in μM range) was also detected in the culture media under hypoxic growth of a few Aspergilli [26]. Putative ldh loci were identified from in silico analysis of published genome sequences of Aspergilli, including A. niger [32,33]. In this context, functional annotation of A. niger ldh and exploring its role in L-lactate formation is important. Five out of 272 hits in A. niger ATCC 1015 JGI genome database (v4.0) are annotated as putative NAD-dependent lactate/malate dehydrogenase ( Table 2); others are either putative cytochrome-dependent dehydrogenases or hypothetical proteins [34]. A blastp analysis, with three different ldhA sequences (R. oryzae, AAF74436.1; A. nidulans, AN5842; mouse, BC094019) as queries, also retrieved one of these five putative ldh from JGI genome database (JGI protein id: 1094595, Table 2). Further, this sequence corresponds to An04g08220 locus (putative ldhA) in A. niger CBS genome [32,33]. This putative ldhA sequence contains one intron and shows around 30% amino acid sequence similarity with R. oryzae LDH (isoform A). The NADH binding sites are conserved in this putative ldh from A. niger; but the LDH signature sequence at the active site (VGVRDSES) is not well conserved. The catalytically important H residue is replaced by an R residue. This active site His (H193 of mouse LDH) is conserved in all functional LDHs [35]. This residue is also conserved in putative LDH from other Aspergilli except for A. niger and A. fumigatus (S1 Fig). The other putative NAD-dependent lactate/malate dehydrogenases ( Table 2) do contain this H residue. However, a comparison of their full length protein sequences suggests they may be malate dehydrogenases and hence they were not considered.
A functional annotation of the putative ldhA ORF (JGI protein id: 1094595) was attempted. The genomic clone, containing a predicted 90 nt intron and encoding a 308 residue protein, was fused to the A. niger citrate synthase promoter (PcitA) (pCBΔXCAnldh) for constitutive expression in A. niger. Around twenty transformants (through bar selection) were obtained and the integration of PcitA-Anldh cassette was confirmed by genomic PCR. None of these transformants displayed significant increase in their LDH activity (activity was comparable to that of the parent strain). The functionality of this ORF was also tested by expressing the corresponding cDNA in E. coli. For this, cDNA was prepared from one of the A. niger transformants (the intron was spliced as expected), cloned in pET-28a and expressed in E. coli BL21 (DE3). However, the expressed protein was not active on different substrate combinations like L-lactate, D/L-lactate, ethanol, NAD + and NADP + (data not shown). An R174H site directed mutant was constructed to see if this made the putative A. niger LDH functional. This mutant protein also did not show any LDH activity. The putative ldhA in A. niger (JGI protein id: 1094595) therefore does not code for a functional LDH in E. coli.
Expression of heterologous mouse ldhA (mldhA) in A. niger Since attempts to identify functional ldh gene(s) from A. niger genome were unsuccessful, a heterologous ldh sequence was expressed to divert the carbon flux from pyruvate towards lactate in A. niger. A range of ldh sources have been evaluated for fungal lactate production since the optimal carbon distribution at the pyruvate node is dependent upon the properties of LDH employed [12,36,37]. In the earlier two reports with Aspergilli, bovine and R. oryzae ldhA genes were used to achieve LDH expression [21,22]. However, the A. oryzae strains constructed to express R. oryzae ldhA genes did not accumulate detectable amounts of lactate [21]. Expressing LDH with appropriate kinetic features is desirable for better lactate yields. Different branches of the A. niger pyruvate node were scrutinized and the kinetic and regulatory properties of different enzymes at this node were analyzed. With micromolar intracellular pyruvate levels (40 μM, [30]) and correspondingly low Km values for different enzymes (Fig 1), choice of an LDH with low Km for pyruvate and high K i for lactate was obvious. Accordingly, mouse ldhA (mldhA) having low K m for pyruvate (0.13 mM) was chosen for expression. Promoters of glycolytic pathway enzymes namely, Ppki and PgpdA were employed earlier to manipulate oxalate and itaconate production in A. niger, respectively [15,20]. However, ldh expression for lactate production in fungi was earlier achieved through various promoters like yeast PDC1 [11,36], A. oryzae sodM [21] and A. nidulans gpdA [22] genes. The fact that A. niger is a major citrate producer with a high glycolytic flux makes its own citrate synthase promoter (PcitA) an ideal pick. The strong constitutive A. niger PcitA was also selected for as it was active throughout growth on MM and AM [24]. The compact PcitA (0.5 kb) was used successfully to express both homologous and heterologous CDSs in A. niger [24,38]. Further, it is comparable in strength to the well established promoters like PglaA and Pgpd [39]. Not surprisingly, the choice of mldhA in combination with PcitA for LDH expression resulted in good titers of lactic acid (see below).  [40], MAE-malic enzyme [41], PDC-pyruvate decarboxylase, PDH-pyruvate dehydrogenase complex, PKI-pyruvate kinase [42] and PYC-pyruvate carboxylase [43].
Respective K m values for the enzymes are given in brackets. These are either taken from Aspergillus literature or for the corresponding yeast enzymes from BRENDA (www.brenda-enzymes.org).
The plasmid pCBΔXCmldh (bearing PcitA-mldhA gene construct, see Material and methods section) was linearized and used to transform A. niger NCIM 565. Most of the bar + transformants displayed significantly higher LDH specific activity (in cell-free extracts) than the parent strain. No extracellular (spent medium) LDH activity was found in any of these transformants. The pyruvate reduction rates were always higher than the corresponding lactate oxidation rates; lactate oxidation is a better measure of specific LDH activity. Negligible yet consistent lactate oxidation activity was observed in the parent strain; that the rudimentary activity may be due to endogenous LDH cannot be excluded at this point. That A. niger may contain an endogenous LDH (or LDH-like) activity is discussed below.
Six bar + transformants displaying a range of LDH specific activities (two highest-D5, C12; two intermediate-C2, C7; and two basal-C16, C3) were selected for further analysis ( Table 3). The enzyme activity staining results were consistent with the corresponding LDH specific activities measured for these six transformants (Fig 2A). The integration of PcitA-mldhA DNA into the genome of the transformants was confirmed by genomic PCR. A 1.0 kb amplicon (with primers citF4 and ldhXR1) was obtained for all the transformants except C3 (Fig 2B); this is consistent with the corresponding LDH activity data (Table 3). Integrated DNA could also be picked up in Southern blots (not shown). Since the DNA integration events are random, the observed differences in LDH specific activity of the transformants may reflect either copy number effects or locus specific transcriptional effects. Therefore, PcitA-mldhA copy number in the genome of these A. niger transformants was determined by qPCR ( Fig 2C). All the transformants (except C3 strain, which was however bar + ) had at least one copy of PcitA-mldhA cassette integrated in their genome (Table 3). There was no linear correlation between the copy number integrated and LDH specific activity. Transformants with only one copy of PcitA-mldhA integrated (C7 and C16 strains) had different LDH specific activities. The D5 transformant with 4 copies of PcitA-mdlhA showed higher LDH specific activity than C12 and C2 transformants having 11 and 13 copies of PcitA-mdlhA, respectively. This could possibly be the effect of integration context on expression levels. While marginal LDH (lactate oxidation) activity was observed in the parent strain, as expected, it was devoid of the PcitA-mldhA cassette. Similar analysis in the case of A. oryzae ldh transformants is not available [21]. The LDH activity in A. brasiliensis ldh transformants increased with ldhA gene copy number up to 6 copies. But LDH activity gradually decreased as the gene copy increased above 6 [22].

Lactate formation in mldhA transformants
The parent A. niger NCIM 565 strain is incapable of making L-lactic acid and if any, submicromolar levels of lactate are detected in its cell-free extracts. With the exception of C3 strain, L-lactate was detected in the spent medium (extracellular) of all the transformants grown in MM (without pH regulation) for 24 h (Fig 3). Intracellular lactate (in the cell-free extracts) was also detected in these transformants and the levels were invariably higher than those found in the spent medium. The levels of citrate in all the transformants however remain unchanged. In general, lactate levels were positively correlated with the LDH specific activity (Fig 3), and not the mldhA copy number (see Table 3), of the transformants. The transformant D5 is an exception in that, despite the highest LDH specific activity (albeit with only 4 gene copies integrated), it had lower lactate levels when compared with C12 strain. Strain D5 also conidiated poorly on PDA plates. Increasing LDH specific activity in transgenic S. cerevisiae [37], C. sonorensis [12] and A. brasiliensis [22] had a positive impact on lactate yield. The C12 transformant strain of A. niger showed maximal extracellular lactate levels on MM containing 1.0 percent glucose (Fig 3). This transformant is deposited in the Microbial Culture Collection at NCCS, Pune, India (Accession number MCC0019). The C12 strain was further tested under different growth conditions for lactate production.

Lactate formation by the transgenic A. niger C12 strain
Growth on different glucose concentrations. The effect of increasing initial glucose concentrations on lactate production by the C12 strain was studied. The LDH specific activity in this strain was not significantly different (range 130-180 U/mg protein) when grown for 24 h on MM with different glucose amounts (1 to 10 percent); whereas the corresponding LDH specific activity of the parent strain ranged between 8-17 U/mg of protein. Lactate was detected both in the spent medium (extracellular) and in the cell-free extracts (intracellular) of C12 strain (Fig 4). The lactate levels were unaffected by increased glucose in the growth medium. Intracellular lactate levels after 24 h growth were invariably higher (between 30-40 mM) than those found in the spent medium (around 1.5 mM). It was also instructive to measure citrate levels as A. niger is a recognized citrate producer. While the intracellular citrate remained steady (between 7-9 mM), its levels increased in the spent medium with increasing glucose; similar results for citrate were obtained with the parent A. niger strain (Fig 4). Detection of TCA cycle intermediates (malate and succinate) were reported with transgenic A. oryzae and it was suggested that excess glucose may induce pyruvate run-off into the TCA cycle [21].
Lactate fermentation on MM. An extended time course of lactate formation by C12 strain was monitored by growth on MM supplemented with 60 g/l of glucose. While their glucose consumption was comparable (Fig 5B), the C12 strain formed less biomass than the parent strain during the lactate production phase (day 2 to day 4; Fig 5A). The LDH activity in C12 strain was detected throughout the seven days of growth (Fig 5D). The L-lactate levels and  Table 3). Arrow indicates the data for C12 strain. LDH specific activity (as also the total LDH activity) peaked on day three. By this time, C12 strain produced 85 mM (7.7 g/l) of extracellular L-lactate from 333 mM (60.0 g/l) of glucose; with an overall yield of 13 percent (g lactate/g glucose) (Fig 5E). The pH of the spent medium decreased to around 3.0 (Fig 5C) upon lactate accumulation. This may not be an issue as A. niger is tolerant to and capable of growth in acidic pH particularly during acidogenesis [23]. However, lactate production by engineered yeasts is adversely affected in non-neutralizing media; addition of CaCO 3 significantly improved the lactate yield [10,12,36]. Therefore, lactate secretion by C12 strain was also monitored under neutralizing conditions-on MM buffered with CaCO 3 (30 g/l). The medium pH was stable between pH 6.0-6.3 during the course of fermentation; with a maximum extracellular lactate concentration of 70 mM on day four (not shown). While addition of CaCO 3 in MM had no effect on lactate secretion by C12 strain, extracellular lactate did not disappear (see below) at later growth stages. Addition of CaCO 3 had no significant effect on lactate titers and conversion yields in the case of A. brasiliensis ldh transformant. However, the nature of nitrogen source in the medium affected the lactate titers [22]. The recent report on lactate fermentation by engineered A. oryzae provides data only with CaCO 3 -supplemented media [21]. While CaCO 3 could be added to production media, undesirable costs to downstream processing of lactate may accrue [1].
Intracellular lactate concentrations have been reported only in C. sonorensis engineered yeast [12]. Lactate concentrations inside C12 strain were comparable to that secreted in the non-neutralizing MM (Fig 5F). Nevertheless, intracellular lactate levels were invariably high at all the glucose concentrations tested (Fig 4). Lactate is known to be actively transported and hence could be a bottleneck. Over-expression of lactate permease (encoded by JEN1) improved lactate production by an engineered S. cerevisiae [37]. Presence of a functional lactate transporter (lacA) was also demonstrated in R. oryzae [44]. A. niger genome harbors a putative lactate transporter gene (NCBI accession number CAK42727), which is homologous to JEN1 of yeast. Engineering a functional lactate transporter might augment lactate secretion in A. niger.
Since A. niger is acid tolerant and a prolific citrate producer [23], a comparison of lactate and citrate formation by the C12 strain was of interest. Both A. brasiliensis and A. niger belong to black Aspergilli but the effects on citrate levels due to ldhA expression in the former are not known [22]. L-Lactate levels were always far higher than citrate levels of C12 strain (Fig 5E and  5F). Intracellular citrate in C12 strain remained largely steady whereas extracellular citrate levels were very low. This pattern of citrate levels (both extracellular and intracellular) was comparable to that of the parent strain under all growth conditions tested (Figs 4, 5E and 5F). Therefore, inducing lactate formation by mldhA expression does not appear to perturb citrate levels in A. niger. This is an advantage in lactate fermentation in MM with minimal interference of citrate.
Lactate fermentation on AM. Citric acid fermentation conditions are well established in A. niger. Inducing lactate formation by mldhA expression in C12 strain does not appear to  influence citrate levels when grown in MM. This was tested further by growing C12 strain in AM (conducive to citrate production). Despite the presence of active LDH throughout the course of fermentation, both extracellular and intracellular lactate levels in the C12 strain were negligible (Table 4). However, both parent and C12 strain of A. niger displayed high citrate levels. Citrate synthase activity is present throughout the acidogenic growth of A. niger [23]. In the present study, citrate synthase promoter was employed to express mouse ldhA [24]. It is interesting that minimal lactate was produced by the C12 strain grown on AM. Pyruvate availability may be a factor as pyruvate carboxylase is also active during acidogenesis [23].
Lactate fermentation under hypoxic and nitrogen starvation. The conversion of glucose to L-lactate by pre-grown mycelia of C12 strain was assessed under hypoxic conditions and on MM devoid of nitrogen source. After 48 h incubation in these two conditions, no significant increase in biomass was observed whereas extracellular lactate levels remained around 5 mM. In a similar study, lactate yield by the parent strain was negligible (10-15 μM). Lactate formation in C12 strain therefore appears to be a growth associated phenomenon.
Among all growth conditions tested, maximum lactate secretion by C12 strain was obtained on non-neutralizing MM with 6 percent glucose. Lactate was secreted within 3 days of fermentation which is less compared to 4 and 10 days required by engineered A. brasiliensis and A. oryzae, respectively (Table 5). Although the lactate yield obtained was low, it is comparable to other engineered fungi grown on non-neutralizing media (Table 5). Further improvements can be achieved through media and growth optimization. More interestingly, lactate and citrate production could be separated based on growth on two different media. Exploring lactate production by C12 strain on other carbon sources also merits further attention. Lactate utilization by A. niger C12 strain Very little is known about lactate metabolism in Aspergilli [46]. A. niger was unable to utilize and grow on L-lactate as sole carbon source, both on liquid and solid MM. Expression of a functional LDH was expected to support the growth of C12 strain on L-Lactate; however, this was not the case. Besides unfavorable kinetic features of mouse LDH for lactate oxidation, uptake of lactate could be an issue. Efforts to feed lactate at lower pH values (pH 3.0 and pH 5.7) and also as methyl lactate were unsuccessful. The C12 strain (as well as the parent strain) grew very poorly on other three-carbon compounds like L-alanine, glycerol or glycerol plus lactate. A. niger is incapable of utilizing ethanol as a carbon source [32]. An inefficient gluconeogenesis in A. niger is one possibility. Interestingly, pre-formed intra and extracellular lactate levels decreased on prolonged growth of C12 strain in non-neutralizing MM (see Fig 5E and  5F). Disappearance of lactate only after glucose exhaustion suggests its reutilization by this strain. Such a lactate utilization/ reutilization possibility was not examined in studies with A. oryzae and A. brasiliensis [21,22]. Both C12 and parent strains were fed with additional lactate (20 mM) after 5 days of growth on MM (6 percent glucose, without pH buffering). Surprisingly, decrease in added lactate was observed for both the parent and the C12 strain within 24 h of further growth. These results point to utilization of lactate through an endogenous enzyme of the parent strain (and not via the expressed mouse LDH). However a mechanism for the observed lactate utilization in A. niger (Fig 5E and 5F) remains to be elucidated. Extracellular lactate decreased after glucose consumption, both in S. cerevisiae [47] and C. sonorensis [12]. It was proposed that such lactate reutilization may be a strategic response to weak acid stress. S. cerevisiae utilizes L-lactate via a mitochondrial L(+)-lactate:cytochrome c oxidoreductase (encoded by CYB2) and disruption of CYB2 improved the lactate production [48]. Lactate yield marginally improved in A. oryzae when a putative ldh (AO090023000871) locus was disrupted [21]. Putative NAD-and cytochrome-dependent ldh(s) are also known in A. niger and these need further attention.

Conclusions
The high acidogenic potential and glycolytic flux make A. niger an attractive target for the production of lactic acid. Its genome was analyzed for potential ldhA genes for functional expression. While A. niger may contain an endogenous LDH (or LDH-like) activity, an ldhA gene coding for such an activity could not be identified. Considering the metabolic features of the A. niger pyruvate node, the LDH expression construct was designed based on sequence comparisons and using an endogenous promoter relevant to its acidogenic metabolism. The integration of PcitA-mldhA DNA led to LDH expression and resulted in transformants that gave significant lactic acid titers. Lactate formation was analyzed as a function of different growth media, hypoxia and nitrogen starvation. Although A. niger does not utilize lactate as a sole carbon source, it was able to re-utilize secreted lactate subsequent to glucose consumption. Interestingly, the formation of lactate and citrate by the C12 strain could be segregated by choosing different growth media. Already an industrial favorite, A. niger promises to be a good platform to produce lactate as yet another organic acid.
Supporting Information  Table. QPCR data for determining PcitA-mldhA copy number in A. niger mldhA transformants. (DOC)